Site work and new construction of a pre-engineered storage facility in Douglas, Georgia. Completed plans call for the construction of a 1,440-square-foot pre-engineered storage facility; and for site work for a pre-engineered storage facility.

The City of Douglas reserves the right to accept the lowest, most acceptable bid and reserves the right to accept or reject any or all bids. No late bids or email bids will be accepted. All bids shall be submitted upon forms provided by the City of Douglas. May be obtained by writing to: City of Douglas Purchasing Dept. P.O. Box 470 Douglas, Ga. 31534 Or by contacting Nikki Thompson, Purchasing Agent, a (912) 389-3463 The City of Douglas reserves the right to waive any technicalities or irregularities so that an award can be made in the best interest of the city. Bids are to be F.O.B. Destination 123 W Cherry St., Douglas, Ga. 31533 The City of Douglas is an equal opportunity employer, including nondiscrimination in employment of the disabled. For further information concerning this bid contact Nikki Thompson, Purchasing Agent at (912) 389-3463 or email purchasing@eityofdouglasga.gov. For technical questions, please call Casey Wright, Fire Chief, at (912) 384-4815. Specifications: 1440 - Doublewide (Base) (2)ll'-8" x 6O'-O" Modules ****Nominal 24' X 60' Occupancy: Business Construction Type VB (Adult Education) State Code Requirements & Insignias IBC/GA Georgia State Approval - State codes only ASCE/SEI 7 Risk category II 115 MPH Wind Speed Ultimate Wind Speed (Vult) 0.1b ground snow load Roof live load 20 lb. Floor load Business Occupancy - 100 lb. live load (corridor) 50 lb. Live load (offices) and 2,000 lb. concentrated load over 30" x 30" areas Destination: Douglas, Georgia Chassis: 120 - ll'-8" wide outrigger w/ 95.5" I-Beam spacing, Outriggers & Crossmembers spaced (As required) 12" I-Beam (M12xl0) Hitches are detachable New Tires are provided - Drivers are responsible for spares Axles - Under-slug axles are included City of Douglas Fire Department 24' x 60' Doublewide Modular Building Bid # 66812-24-0008 Floor Section: Standard bottom board material 2" x 8" floor joist @ 16" O.C. (12' Wide Modules) 2' x 8" Double Perimeter Included Double layer 5/8 floor decking Floor decking held back 2.5" and a % plywood filler on the mate line 1440 - VCT (Armstrong Brand) installed per the print - VCT will be installed 50% off-set with checkerboard pattern (unless otherwise noted) Specifications: 1440 - Doublewide (Base) (2)ll'-8" x 6O'-O" Modules ****Nominal 24' X 60' Occupancy: Business Construction Type VB (Adult Education) State Code Requirements & Insignias IBC/GA Georgia State Approval - State codes only ASCE/SEI 7 Risk category II 115 MPH Wind Speed Ultimate Wind Speed (Vult) 0.1b ground snow load Roof live load 20 lb. Floor load Business Occupancy - 100 lb. live load (corridor) 50 lb. Live load (offices) and 2,000 lb. concentrated load over 30" x 30" areas Destination: Douglas, Georgia Wall Section: 84 - 2" x 4" Interior wall height: 8'-6" - Unless otherwise noted, interior walls will be constructed with #2 2x4 studs 16" O.C. with single 2x4 top and bottom plates 15 - Plumbing walls constructed per print 2x6 Exterior wall height 8'-6" (2x6 sidewalls) (Double top-plate on exterior walls, as required) 2" x 6" Exterior end walls full height Interior trim package: Standard battens 5/8" VCG (Vinyl covered gypsum - Type X) 248 - FRP wall panel laid-up on gypsum (Class "C") ***Full height FRP on the restroom walls only*** (FRP = Fiberglass Reinforced Panels will be installed over raw gypsum and include vinyl base covering) 336 - 4" VCB (Vinyl Cover Base) Vertical tie-down straps are on all four corners Interior Door Section: 3 - 36" x 80" S.C. Flush door w/ steel jamb (Includes Timely or Redi-Frames with lever. Door frame is painted the standard bronze finish color & door is Imperial Oak.) 1 - 36" x 80" Flush imperial Oak Bi-fold door 3 - Door closers on interior doors per the print 3 - Keyed interior door locks per the print 3 - 6" x 30" Glass view block Roof/Ceiling Section: Truss spacing @ 24" O.C. (UT12w) Transverse truss (Engineered truss) 7/16" x 4 x 8 EPDM underlayment 12" Peel & stick mate-line tape - White Roof covering: 45mil. White EPDM (Doublewide) ***with 15-year roof warranty*** Ceiling finish: 2'x2' T-grid (Acoustical) Ceiling finish is 8'-0" above finish floor 60 - 4-Layer 24" ridge-beam construction: Continuous / Full length of Module (This beam will be constructed from 4-layers of %" structural grade plywood installed as required and fastened as per approved fastening schedule.) 48 - End projection: 24" roof over hang ' No over-hang (no overhang over 60' the sidewalls) No attic ventilation is included Side wall type hurricane straps (Please note that if foundation drawings or calculations are provided, they will be calculated based on Frame Tie-down straps, Not side-wall tie-down straps.) Special instructions for Purchasing/Production ***with 15-Year roof warranty Plumbing Section : 2 - Restroom description: Single station handicap RR 2 - Standard lavatory: Wall mount types (includes a standard faucet and mirror) 2 - Handicap Sink Protection: sock for P-trap 2 - Water closet Type: HC accessible w/std. grab bars (includes a vertical grab bar, standard toilet paper holder) 1 - 10-gallon water heater, located inside the base cabinet. 2- 18" x 36" Stainless steel mirror - B-165 Drain waste lines are PVC (Please note that all manifolding is done on-site by others) 1 - Supply lines are PEX 1 - Rough-in plumbing for a refrigerator icemaker (Unless otherwise noted, all appliances are by others Electrical Section: 2 - Panel type: Standard 125 AMP (125 Amp - 120/240V 1-Phase panel boxes) 16 - 2' x 4' Standard "T-grid type" LED Lights (Balance) 2 - 2' x 2' Standard "T-grid type" LED lights (1) in each bathroom 4 - Standard 60-watt porch light with photo cell 7 - Wall mounted Occupancy Sensor 2 - Combo dual head emergency Iight/exit sign (Quantity is shown budgeted, actual quantity will be as required after review and per final approved customer drawing.) 2 - Exterior emergency light remote heads as required (Exterior type to match porch lights.) 20 - 2" x 4" junction box with 3/4" conduit (standard) with pull strings. (These junction boxes will be studded-up into the attic cavity; all boxes and conduit are empty, all wiring and devices for monitoring, alarms and security are entirely by others.) 2-80 CFM exhaust fan (no light) (1) in each bathroom. 110 Volt receptacles @ approximately 12' O.C. (Standard) 2 - Receptacles Type: 120 Volt 20 Amperage (Standard 120-volt AC 20 Amperage duplex receptacles) 2 - Receptacles Type: 120 Volt Tamper Resistant Recept (Standard 120-volt AC tamper resistant duplex receptacles) Receptacles / Switches / Covers are white 4 - GFI receptacles are required (1) in each bathroom and (3) Ded. GFI's in the breakroom (GFI = ground Fault Interrupter) 4 - Exterior use GFI w/ weather proof cover (Locations TBD.) (In use with exterior rated GFI receptacle) 3 - Duplex 120 Volt dedicated receptacle - Located in break area for customer provided and installed appliances. 1 - Heat tape receptacle - GFI protected - located adjacent to water in-let. (Underneath the floor. Any and all heat tape is entirely by others.) 1 - Quad floor box receptacle / J-box combo *** The floor box will have 1/z inch conduit ran to the nearest wall and stubbed up into the ceiling cavity, above the finish ceiling. (Location TBD) - 4" x 4" floor rated box with brushed nickel cover includes a 15 Amp duplex receptacle with low-voltage divider and an empty duplex space for Cat5E with and a % inch EMT conduit ran to the nearest wall and stubbed up into the ceiling cavity, above the finish ceiling. Standard race-way: 12-2 Romex wiring Race-way: M.C. cable wiring only above the T-grid 4 - (4) 20 Amp Quad receptacles (locations TBD) 4 - Receptacle and Blank 2x4 J-Box for customer provided and installed monitor/TV, to be mounted @ approximately 80 inches AFF. Factory to provide Backer Boards in these areas. 2 - (2) Ceiling mounted 20 Amp outlet's (location TBD) 1 - Please note that all wiring and devices for alarms, mass-notification systems, door alarms, security, speakers, monitoring, and controls are entirely by others onsite. 1 - Please note that All Equipment Racks, Cable Trays, and communication components are entirely by others onsite2 - 36" x 80" Steel door with 6" x 30" vision panel 2 - Standard lever (Tell Grade 2 keyed) (Restroom Doors only) 4 - Standard closer 2 - Standard panic hardware 4 - ***Exterior Doors to be Keyed Alike. Insulation Section: Exterior wall includes R-19 unfaced (Requires 2" x 6" minimum exterior walls) (The noted insulation value is only an estimate and is subject to change based on final engineering) R-13 Interior wall sound reduction batts (The noted insulation value is only an estimate and is subject to change based on final engineering) Floor includes R-30 unfaced (The noted insulation value is only an estimate and is subject to change based on final engineering) Roof includes R-30 unfaced (The noted insulation value is only an estimate and is subject to change based on final engineering) The City of Douglas reserves the right to accept or reject any or all bids submitted at its discretion. Bid Award Letter and a Tabulation will be sent to all responding Bidders, after Mayor and Board of Commissioners approve the bid by way of e-mail, so please make sure that your E-mail address is included in your Bid Packet.