Renovation of a warehouse / distribution facility in Stanhope, New Jersey. Completed plans call for the renovation of a warehouse / distribution facility.

As of 7/31/24, this project has not yet been awarded. A timeline for award has not yet been established. DPW Storage, Leaf and Branch Waste Bid. It is the intent of theses specifications from the Township of Byram, located in Sussex County, New Jersey, to provide an outline for the minimum most acceptable specifications for the purpose of providing a steel-walled storage facility for the Department of Public Works. a. Width 30' b. Height 16'4" c. Length 120' d. Truss Spacing 8' e. Roof pitch 4 1/2 f. Lower Chord 1/12 g. Peak Height 22' 10.5" h. Soffit Height 17'1" 3.0 Foundation a. Concrete Columns In Ground. b. Reinforced precast concrete column with an internal threaded adjustment bracket set in a readymix poured footing set below frost depth or a minimum of 4'-0" below building grade. c. Fastened to a laminated wood column with an internal column connector bracket. d. Treated Wood splashboard system. 4.0 Siding a. South, East, North, West wall(s) Fluoroflex or equivalent 1000 Hi-Rib Steel Minimum .019 (Fastened with Stainless Steel Screws). 5.0 Wainscot a. South, East, North, West with 36" tall Fluoroflex or equivalent 1000 Hi-Rib Steel Minimum .019 wainscot (Fastened with Stainless Steel Screws). Protective Liner b. South, East, North, West wall(s) with 7/16" thick OSB by approx. 32" tall Protective Liner. 6.0 Roof a. Hi-Rib Steel Minimum .019 (Fluoroflex 1000) (Fastened with Stainless Steel Screws) with VentA-Ridge, 122 LF of (1) rows of Aluminum Snow Retainers on North side, 122 LF of (1) rows of Aluminum Snow Retainers on South side. 7.0 Overhangs a. South, North wall(s) 1' Wide Vented Sidewall Overhang with Standard 6" fascia, 5" Gutters and 3"x4" Downspouts, with elbows at base. b. East, West wall(s) 1' Wide Non-Vented End wall Overhang with Standard 6" fascia 8.0 Condensation Control a. Roof shall be by formed dry panel. 9.0 Doors a. 3' x 6'8" 9 Lite Tempered Glass in Leaf with Embossed Crossbuck Fibersteel Walk Door(s) outswing right hinge with keyed lever lockset, closer b. 3' x 6'8" 9 Lite Tempered Glass in Leaf with Embossed Crossbuck Fibersteel Walk Door(s) outswing right hinge with closer, lockset 10.0 Overhead Door Opening a. 14'0" x 14'0" Overhead Door Opening, 14' 2" X 14' 1" Panel, OHD/Operator requires 1' 4" Headroom, Available Headroom is 2' 1", See Subcontract Section for Detailed Door Information b. Framed Openings c. 39' X 15' (585 sq. ft.) Framed Open Wall Cross Partition Wall a. Cross partition wall 40.58333' from left end wall of building with columns on right Left Side Finish Gable Finish: Hi-Rib Steel (.019 CQ FF1000) Siding Finish: Hi-Rib Steel (.019 CQ FF1000) Wainscot: 36" tall Hi-Rib Steel (.019 CQ FF1000) Concrete Floor a. Install 30' x 80' x 6" thick concrete floor reinforced with Fiber Mesh with a Broom finish. Includes expansion joints, 6 mil poly vapor barrier, forming at OHD doors, sawcut control joints, and one coat sealer. b. Install 14' 2" X 14' 1" Sepia Raynor Insulated M200C 2" R18.30 Door with 2" Raynor Heavy Duty Track and hardware, Stucco Panels, Door/Operator requires 1' 4" headroom, 3" Gray rubber bottom seal. Operator is not included. Available Headroom is 2' 1" 13.0 Debris Collection Area a. 30'x40' debris collection area to be lined with (14) rows 2x8 T&G splashboard. b. Install 30'x40' Asphalt floor consisting of 4" base coarse with 2" top coarse Bid proposals must be accompanied by a certified check, cashier's check, or bid bond in the amount of ten per centum (10%) of the total amount of the bid, but not in excess of twenty thousand ($20,000) dollars and made payable to Byram Township. The bid bond may also be provided in certified check and cashier's check in accord with provisions within general requirements of this bid. The Township of Byram will award this bid to the lowest responsible bidder in accordance with New Jersey Local Public Contracts Law.