Demolition, site work, paving and new construction of a mixed-use development in Middletown, Pennsylvania. Completed plans call for the construction of a pre-engineered storage facility; for site work for a pre-engineered storage facility; for the demolition of a municipal facility; municipal facility; road / highway; for paving for a road / highway; and water / sewer project.

Construction Contract No. T-243.80f001-3-02 General Construction Construction Contract No. T-243.80f001-3-03 Plumbing Work Construction Contract No. T-243.80f001-3-04 Electrical Work Construction Contract No. T-243.80f001-3-05 Hvac Work Project Description The Pennsylvania Turnpike Commission is currently preparing plans for construction of a replacement New Cumberland Maintenance Facility complex on the current Maintenance site and adjacent wooded area to the East. The site is on the Eastbound side of the Turnpike (I-76), from Milepost 243.7 to Milepost 244.5 and North of Marsh Run Road. The project includes construction of four buildings and demolition of existing buildings. The first building will consist of an Administrative Offices area wing connect to a Vehicle Maintenance & Repair wing with three= dedicated service bays, a wash bay, and a welding shop. The Second building is for Equipment Storage, and the third and fourth buildings are salt storage buildings. In addition, the work includes site improvements including, but not limited to, grading, pavement, utilities, fencing, landscaping, underground fuel storage tanks, and a covered vehicle fuel dispensing island. CONTRACT NO. T-243.80F001-3-02 - GENERAL CONSTRUCTION General construction work includes: cast-in-place reinforced concrete; precast concrete; unit masonry; structural steel; steel joist framing; steel deck; cold-formed metal framing; metal fabrication; structural steel sub-framing; metal stairs; exterior rough carpentry; sheathing; glued laminated construction; asphalt fiberglass shingles; vinyl siding, soffit, &trim; architectural wood casework; thermal insulation; weather barriers; metal roof panels; metal wall panels; metal composite material wall panels; sheet metal flashing and trim; roof expansion joint covers; pre-finished aluminum gutters and downspouts; fence type snow guards; firestopping; joint sealants; expansion joint cover assemblies; hollow metal doors and frames; coiling and sectional overhead doors; aluminum-framed storefronts; metal-framed skylights; glazing; louvers; stainless steel doors and frames; FRP doors; gypsum board assemblies; tiling; suspended acoustical ceilings; resilient flooring; fluid-applied flooring; resilient base and accessories; exterior painting; interior painting; high-performance coatings; visual display units; building signage; post and panel/pylon signage; metal toilet compartments; wire mesh partitions; toilet and bath accessories; fire extinguisher cabinets & extinguishers; metal lockers; metal storage shelving; flagpoles; residential appliances; window shades; countertops; vehicle wash equipment; shop equipment; video surveillance equipment; vehicle maintenance and repair equipment; underground fuel storage tanks, pumps & dispensers; aboveground calcium chloride and salt brine storage tanks and pumps; oilwater separator; vehicle lifts and overhead gantry crane. The site work will consist of earthwork, site signage, utilities, bituminous pavement, concrete pavement, fencing, vehicle access gate, and landscaping. Work shall be completed in phases and coordinated with PTC to ensure continuous operation of the New Cumberland Maintenance Section utilizing existing and new facilities throughout construction. Work includes demolition of existing buildings and facilities. CONTRACT NO. T-243.80F001-3-03 - PLUMBING WORK Plumbing work includes: domestic water supply (hot and cold) piping and specialties; sanitary sewer system; plumbing fixtures; meters, gauges, and valves for plumbing & piping; roof drains; packaged air compressor, piping and specialties; natural gas piping; domestic water heater; fire protection piping and sprinkler heads; water storage tank; gaseous pre-action fire suppression systems; fluid dispensing equipment and piping; generator fuel oil piping and plumbing; vehicle fueling piping & plumbing, pipe & plumbing insulation; pipe & plumbing hangers and supports; identification for plumbing piping and equipment; vibration and seismic controls, waste oil tank, pump, & piping; and training others on plumbing system operation & maintenance. CONTRACT NO. T-243.80F001-3-04 - ELECTRICAL WORK Electrical work includes: complete normal and emergency electrical distribution systems; electrical wiring for lighting, equipment, communications & electronic systems, receptacles, and devices; excavation & backfill, concrete, duct bank, manholes, and boxes for underground raceways for power, communication, safety and security systems; normal switchgear packaged engine generator system; transfer switch; switchboards; fuses; disconnect switches; branch circuit panelboards circuit breaker enclosures; enclosed controllers; transformers; conduit and tubing; boxes; wiring & wiring devices; and wall plates; interior & exterior light fixtures; lamps; batteries; supports; poles, bases, & foundations; and lighting controls; grounding and bonding; testing; identification; painting; and training others on system operation & maintenance; fire detection and alarm system; surveillance, security & access control systems; lightning protection systems; transient voltage suppression; and cable trays, underground & internal raceways, conduit, supports and boxes for telecommunication systems. (work does not include telecommunication wiring/cabling, equipment, and devices.) CONTRACT NO. T-243.80F001-3-05 - HEATING, VENTILATION AND AIR CONDITIONING HVAC work includes: geothermal well borings and piping; groundwater source heat pumps; energy recovery equipment; gas fired make-up air equipment; thermal enhanced bentonite grout; hydronic piping; ground loop heat pump piping; radiant heating piping; hydronic pumps; refrigerant piping; HVAC water treatment; metal ducts; air duct accessories; HVAC power ventilators; vehicle exhaust system; air outlets and inlets; condensing boilers; dedicated outdoor air units; split system air conditioners; water source unitary heat pumps; cabinet unit heaters; propeller unit heaters; breechings chimneys and stacks; and packaged engine generator ductwork and exhaust piping; insulation; hangers and supports; expansion fittings and loops; sleeves, sleeve seals, and escutcheons; vibration and seismic controls; meters, gages, and valves; instrumentation and controls; testing, adjusting and balancing; identification; and training others on system operation & maintenance. The intent is to advertise for bids in Summer 2024. For questions concerning this project, the special prequalification process, or the prequalification application and instructions, contact Vincent Buser at telephone:(717) 712-7943; e-mail: vbuser@paturnpike.com. *The value for this project is based on a financial range. The value is listed as the highest possible cost from the range provided by a stakeholder or official project document. CONTRACT NO. T-243.80F001-3-02 - GENERAL CONSTRUCTION - between $38,000,000 to $53,400,000 CONTRACT NO. T-243.80F001-3-03 - PLUMBING WORK - between $2,300,000 to $3,700,000 CONTRACT NO. T-243.80F001-3-04 - ELECTRICAL WORK - between $4,400,000 to $6,400,000 CONTRACT NO. T-243.80F001-3-05 - HEATING VENTILIATION & AIR CONDITIONING - between $2,200,000 to $3,200,000