Renovation of a mixed-use development in Columbia, Pennsylvania. Completed plans call for the renovation of a educational facility.

The Columbia Borough School District is soliciting proposals from qualified vendors for the purchase and installation of a walk-in cooler for the school district. Direct all responses, questions, and inquiries to: Brian Rathgeb Food Service Department Columbia Borough School District 901 Ironville Pike Columbia, PA 17512 Phone: 717-681-2214 Email: brathgeb@columbiabsd.org Provide a Walk-in Cooler that meets commercial specs and heavy use. Walk-In Details - Single Compartment Rectangular Walk-In Actual Exterior Dimensions Temperature 10'-0" X 6'-0" X 8'-6" high 35 F Cooler Floor Configuration Finish Foamed-in-Place 4" Urethane floor panels .100 Smooth Aluminum Metal Finishes Exposed Exterior: 26 ga. stucco acrylume Unexposed Exterior: 26 ga. stucco acrylume Interior Walls: 26 ga. stucco acrylume Interior Ceiling: 26 ga. stucco acrylume All panels are NSF 4" foamed-in-place urethane, UL classified with a flame spread rating of 20. Door Details Hinged Walk-In Door(s) Qty. Description 1 34" X 77'' flush mount magnetic in fitting door with cam-rise hinges, pad-lockable deadbolt handle (exterior doors only), door closer, brushed hardware, fully programmable Intelligent Controller (IC) featuring audio/visual temperature alarm with digital thermometer, high & low set points, energy-saving door frame heater wire, vapor proof light & switch with pilot light. Walk-In Accessories Qty. Description 1 Flex. Strip Curtain, up to 36" x 77" Opening 1 Floor Ramp, Interior (24" deep) for up to 42" door 1 LED Light Fixture, Cooler & Freezer, 48" 2-lamp (-40F or higher operating temp.) Refrigeration Design Criteria Walk-In Location: the box will be indoors in an enclosed room. Refrigeration Unit Location, please note the area to work with is small. Ambient Temp: 90 F Ambient Temp: 95 F Walk-In Temp: 35 F Cooler System Capacity: 7,851 BTUH Walk-In Heatload: Located at altitude 25 ft., above sea level Vents: n/a System AWEF: 7.6 (Cond. Unit) / 9.0 (Evap) Refrigeration Qty. Description Temp. Electrical 1 1.00 HP hermetic scroll air cooled refrigeration system 35F Cooler 208/230/60/3 Includes standard low profile Intelligen evaporator coil Includes 5-Year Compressor Warranty Condensing Unit Model #: FFAM-A10Z-TFC-075 Amp Draw: 7.6A (Each) Evaporator Model #: BEL0060BS6AM Amp Draw: 0.6 A(Fans)/ 0 A(Htr), (Each) Quoting a "Pre-Assembled Remote" refrigeration system. All controls are factory-mounted. Refrigeration lines and refrigerant by others. Labor warranty provided by others. System to use R448a and is supplied with LASA winterization controls. DISCLAIMER: These refrigeration systems have been selected with the assumption that the each refrigerant line-set length will be less than 100 feet and that the evaporator coil will either be at the same elevation, below or no more than 25 feet above the condensing unit. If not, consult the factory American Panel is not responsible for issues that arise due to improper installation 1 Galv Weather Cover 1 Steel Compressor Mounting Stand 1 Winterization Controls, Remote 1 One-year Labor Warranty on Pre-Assemb. Remote Refrig. Systems Custom Park Elementary School Scope of work: Assemble walk-in cooler Hang evaporator Set the condensing unit Install insulated refrigeration line set Install condensate drains for walk-in evaporator Leak check refrigeration systems with 100 psi dry Nitrogen Evacuate systems to 500 micron Perform final wire connections to refrigeration equipment Charge and commission refrigeration systems